Difference between revisions of "Finis"

Revision as of 04:43, 25 September 2007

FINIS Codes

There is now a database system in operation over at FordMondeo.org Feel free to add all your codes to this database and if you have any suggestions on how to improve it then please contact GizzmoAsus.

Aircon

Mk3 Compressor To Condenser.

'O' Ring Seals: 4189236, 1018824, 4370758.

Tube Assembly: 1327303.

Alloy Wheel Parts

Hub Stud: 6789185

Alloy Wheel Nut: 6452292

Set of 4 Locking Wheel Nuts for Alloy Wheels (incl Adaptor): 1056271

16" Cosworth Style Alloy Wheel: 5052063106

Bodywork

   * Mk2 Bumper Bolts: 6426662

   * The 2-Pack Adhesive/Sealer for Spoilers/Side-skirts, etc: 5029631

   * Mixing and Applicator Gun for above: 3831141

   * Front Offside Wheel Arch Liner: 1307004 

Diesel - 1.8TD

   * Rubber Pipe for the boost on the 1.8TD Endura DE Engine: 1067453

   * Lucas Diesel Injectors (Numbers listed are the Lucas Part Numbers):
         o Mk1 : LCR6705301
         o Mk2 : LCR6705301 or LDC - 008R01 (part with the wire) 

Duratec - V6

   * V6 Auto Throttle Cable: 1000264
         o You will need this part if you are upgrading to an ST200 Throttle Body on an early ST24. The standard ST200 cable will bypass the Traction Control Unit 
   * UIM Cover: 1152010
   * UIM Cover Studs (3 Req): 1152011
   * Mk1/2 Fuel Filter: 1022150 (You probably need a new jubilee clip to hold the thing up with for about 50p at the same time!)
   * EGR Valve: 675270
   * EGR Solenoid: 6327187
   * EGPD Valve: 7117213
   * Lower Rear Engine Mount (Ford call it a "Rear Torque Restrictor"): 1097914
   * V6 Anti-moose kit (to stop moosing noise on pre-2000 V6 cars)
         o New intake assembly: 1025296
         o Clip: 6473358 
   * Mk1 exhaust manifold to downpipe parts:
         o Long stud: 6701066 
   * Throttle body to plenum chamber studs: 6959167
   * ST200 Throttle Body Bits
         o ST200 Throttle Body: 3997172
         o Throttle cable Bracket - 3997383
         o ST200 bellows (between Maff & TB) - 4050122
         o ST200 throttle cable - 1065575
         o Gasket (TB to UIM) - 6824019
         o Stud (top left corner of TB) - 3949883 

You will also need a new nut for the TB stud but I don't know what the part number/cost is for that. Depending on what type traction control you've got you may not need the ST200 throttle cable. If your throttle cable comes off the TB & round the front of the car & into a box by the washer bottle reservoir you don't need the ST200 throttle cable BUT you will need to make a new nipple to fit the ST200 TB onto your existing cable.

   * Insulator Assembly (rear drop link rubbers): 7144202
   * Sensor Assembly (EGR Valve): 7321419
   * Gaskets needed to clean V6 secondaries
         o Upper Inlet Manifold to Lower *2: 3523225
         o Lower Inlet Manifold to Block *2: 3902545
         o EGR Valve to UIM: 6326205
         o Throttle Body to UIM: 7318043 
   * Idle Speed Control Valve for V6: 4429072
         o Gasket for above: 6326728 
   * IMRC: 4344504 - It's listed as control assembley c95973 g4(wp) 

Exterior

   * Black Number Plate Surround - Mk1 Hatch: 1014460
   * Mk1 Headlight Plastic Lens Diffusers (the ones which tend to go yellow): 7304997 & 7304999
   * Drivers' Side Jacking Point Cover ST24: 1038980
   * Mk1 Front Bumper Grille (With Fog Lamp Fitment): 7022605
   * Mk1 Rubbing strips (standard dark grey rubber):
         o Front Offside Wing: 6809594
         o Front Nearside Wing: 6809595
         o Front Offside Door: 6809598
         o Front Nearside Door: 6809599
         o Rear Offside Door: 6809600
         o Rear Nearside Door: 6809601 
   * Windscreen washer non-return valve: 6747269
   * Gas Tailgate Strut Mk1 Hatch w/Spoiler: 1020156
   * Fog light cover for the ST24 (passenger side): 1038900
   * Front Foglight Surrounds (RSAP) - Offside: 1038899, Nearside: 1038900
   * ST Sideskirt Jacking Covers
         o Front Offside: 1038980
         o Front Nearside: 1038982
         o Rear Offside: 1038981
         o Rear Nearside: 1038984 
   * Mk3 Styling
         o "MONDEO" badge for the boot, square typeface not the Mondeo script: 1132601
         o "ZETEC" boot badge: 1132604
         o "V6" badge: 1129408
         o Battery Box (2 parts): 1115415, 1136193
         o Clear Side Repeaters (Each): 4333985 or 4441802
         o Front and Rear Mud Flaps: 1124589 and 1139309
         o 2005+ Front Lower Bumper Grille - Honeycomb Effect: 1365407 

Interior

   * Spare Wheel Bracket (the white plastic thing that goes on the board and the metal pin): 6827985
   * Mk1/2 Revised heater pack and wiring assembly to replaces the resistor pack that causes a burning smell and/or loss of cabin fan settings 1, 2, and 3:
         o Revised Wiring Assembly: 1056972
         o Revised Resistor Pack Assembly: 1066902 
   * Mk1 Door ajar switch (Offside Front - may be same for others): 1035451
   * Mk1 Door alarm switch (bit around lock barrel triggered by cams on the barrel to send signal to alarm module:
         o Offside: 6950445
         o Nearside: 6950444 
   * Mk1/Mk2 Raven (black) Mirror Blanks (interior screw hole cover): 1030927
   * Mk3 Ghia Rear Interior Lamp Frame (not the lamp unit itself): 1256557
   * Walnut Drivers Dash Panel Mk2: 1114554
   * Wood effect (Paddock Grain) Gearknob: 1073614
   * Wood effect (Paddock Grain) Handbrake Handle: 1099898
   * Wood effect Heater Panel: 1114547
   * Wood effect Light Panel: 1114554
   * Ghia Maplight & bulbs (shade: pumice): 6803425
   * Ghia Maplight & bulbs (shade: opal): 1029487
   * Silver door-puller inserts: 1097347 right, 1097348 left
   * Silver finish, alloy look gearknob: 1000046
   * Mk1 rechargeable style Glovebox torch (longer model with orange light and magnetic base): 6690146
   * Carbon fibre sill foil kit: 1206336
   * Under-handbrake rubber mat: 1036369
   * Parcel Shelf Strings (grey): 6906238
   * ST200 Front Mats - Passenger: 1086864, Driver: 1086810
   * Mk2 Rubber floor mats: front (pair) 5027732, rear (pair): 5027733
   * Mk3 Dual Horn: 1151835
   * Mk3 Estate Cargo Securing Net: 5028017
   * Mk3 Glove Box Damper: 1349530
   * Mk3 Pollen Filter: 1349791
   * Mk3 Roof Loom - Front & Rear Courtesy Lights, Vanity Mirror Lights, and Photochromatic Rear View Mirror: 1300519 

Merchandise

   * Mondeo Brolly (black and silver panels with Mondeo written on it, leather handle and a slip case): 1129940 

Security

   * New-style 3 Button Remote Central Locking Unit (DOES NOT include key, key cutting or PATS immobiliser transponder): 1132448 

Service Parts / Consumables

   * Fuses
         o 3 AMP E43b-14A094-AA
         o 7.5 AMP 87FG-14A094-DA
         o 10 AMP D9ZB-14A094-CA
         o 15 AMP D9ZB-14A094-DA
         o 20 AMP D9ZB-14A094-EA
         o 30 AMP D9ZB-14A094-GA
         o 40 AMP 93BG-14A094-DA
         o 20 AMP Square 91AG-14A094-AA
         o 60 AMP Square 91AG-14A094-FA
         o 80 AMP Square 91AG-14A094-HA 

   * Bulbs
         o 5W Capless (Glovebox, Footwell, Side Repeaters, Side Lights) 81AG-13465-AA
         o Dash Cluster/Instruments Replacements (Inc plastic holder) 94AP-13464-AA
         o Main Lightswitch Surround Illumination 93BB-13464-CA
         o Interior Door Handle Surround (Green) 6160568
         o Heater Control Panel Illumination (Mk1) 7358627
         o Heater Control Panel Illumination (Mk2) 85GB-13464-AA
         o Sun Visor Vanity Illumination 93OX-13465-AA
         o Torch Key Bulb 92GG-13464-AA
         o Glovebox Torch Bulb 93BG-13464-AA
         o Automatic Transmission Lever Position Illumination 72GB-13464-AA
         o 21W Capless (Front Direction Indicators) 95FG-13466-AA
         o Front Foglight Mk1 69AG-13009-AA
         o Front Foglight Mk2 69AG-13009-BA
         o Numberplate Light - 5W Festoon 69AG-13465-CA
         o Rear Rooftop Courtesy Light 10W 81AG-13466-CA
         o Halogen 6W Bulb - Front Rooftop Internal Map Lights 96FG-13466-CA
         o Boot Light & Front Rooftop Interior Courtesy Light 83AG-13465-AA
         o Rear Cluster 5W 83BG-13466-BA
         o Rear Cluster 21W 83BG-13466-AA
         o Rear Cluster Duel Filiment 21W / 4W 87BG-13464-AA
         o Philips Vision Plus H1 headlight: 1137015
         o Mk1 Headlight - 55W 69AG-13009-AA
         o Mk2 Headlight - Halogen 55W 94BG-13009-AA 

   * Service Parts
         o Oil Filter - 6937011
         o Spark Plug - 6726180
         o HT Leads - 1012436
         o Brake Pads � 5029147
         o Cabin Filter � 1665410
         o Cam Belt/Pulley kit - 1112530 

Zetec

   * Mk1 Temperature Sender Assembly: 6193368